Efficient utilization of crop residues is an alternative way to overcome feed shortage for livestock feeding. Hence, an experiment was conducted to determine the effect on nutrient intake, milk yield, nutrient digestibility and rumen parameters of total mixed ration (TMR) as mash or block form in comparison to conventional feeding system for a period of 45 days. Accoding to CRD 18 RCC early milking cows (Bos indicus) having average daily milk yield of 3.20±0.14 L/d and divided into three treatment groups. Existing feeding practice at the farm was considered as control group (T₀) fed Napier-3 adlib. and concentrate mixture. In another two groups, animals fed TMR, where one fed as block (T₁) and another as mash form (T₂) with the same roughage and concentrate combination (50:50). All diets contained 16% CP. To determine digestibility of supplied feed, a digestibility trial at the middle of the feeding trial was conducted and also to study the rumen environment (pH, TVFA, NH₃-N), rumen liquors were collected at post feeding intervals of 3, 6, 12, 24 and 36h. Study revealed that fresh feed intakes were significantly (p<0.001) higher in T₀. DMI and CPI were significantly (p<0.001) higher in T₁ group. Significantly (p<0.05) highest milk yields were obtained in T₁ (3.6 l/d) and T₂ (3.49 l/d) and lowest in T₀ (3.35l/d). Milk fat (p<0.001) and SNF (p<0.05) were significantly higher T₁ and T₂. Except ADF, digestibility for most of the nutrient was significantly higher in T₁ and T₂ than T₀. Total volatile fatty acids (TVFA) and ammonia-nitrogen (NH₃-N) were significantly (p<0.01) higher in T₁ and T₂ groups than that of T₀ group. Finally, it may be concluded that TMR, either in block or mash form gives better results in terms of milk yield, milk composition, digestibility and concentration of TVFA and NH₃-N.